本方法適用于工業級、熒光粉級碳酸鋰中質量分數為0.0030%～0.20%的氯化物的測定。                                                                

2   原理                                                                

試料用硝酸分解，在微酸性溶液或乙醇溶液(3＋1)中，以二苯偶氮羰酰肼為指示劑，用硝酸汞標準滴定溶液滴定至紫紅色確定終點。以消耗硝酸汞標準滴定溶液的量計算氯化物的量。                                                                                                                                  

3   試劑                                                                                                                                 

3.1乙醇，3＋1。                                                                                                                                  

3.2硝酸，ρ1.42g/mL，優級純。           &nbs

3.3硝酸，1+1，優級純。                                                                                                                                  

3.4硝酸，3+47，優級純。                                                                                                                                 

3.5氫氧化鈉溶液，200g/L。                                                                                                                                 

3.6氫氧化鈉溶液，40g/L。                                                                                                                                 &n

3.7氯化鈉標準貯存溶液，0.05moL/L：

稱取2.9220g預先在450～500℃灼燒1.5h并在干燥器中冷卻至室溫的氯化鈉(基準試劑)，置于250mL燒杯中，加水溶解后，移入1000mL容量瓶中，以及稀釋至刻度，混勻。

3.8氯化鈉標準溶液，0.005moL/L：

移取25.00mL0.05moL/L氯化鈉標準貯存溶液，置于250mL容量瓶中，以水稀釋至刻度，混勻。                                                                 

3.9硝酸汞標準貯存溶液，0.05moL/L：

稱取8.57g硝酸汞[Hg(NO₃)₂·H₂O，優級純]，置于250mL燒杯中。加入7mL硝酸(1+1)，用少量水溶解，必要時過濾，移入1000mL容量瓶中，以水稀釋至刻度，混勻。                                                                

注：或稱取5.43g氧化汞(優級純)，置于250mL燒杯中，加入10mL硝酸(1+1)和少量水溶解，必要時過濾，移入1000mL容量瓶中，以水稀釋至刻度，混勻。                                                                                                                                 

3.10硝酸汞標準滴定溶液，0.005moL/L。

3.10.1配制：移取50.00mL0.05moL/L硝酸汞標準貯存溶液，置于500mL容量瓶中，補加5mL硝酸(1+1)，以水稀釋至于刻度，混勻。                                                                                                                                  

3.10.2標定：移取三份5.00mL0.005moL/L氯化鈉標準溶液，分別置于250mL三角瓶中，加入40mL水和2～3滴1g/L溴酚藍指示劑，滴加硝酸(3+47)至溶液由藍色變?yōu)辄S色，再過量2～5滴，加入1mL 5g/L二苯偶氮羰酰肼指示劑，以硝酸汞標準滴定溶液，0.005moL/L滴定至溶液由黃色變?yōu)樽霞t色即為終點。平行標定所消耗0.005moL/L硝酸汞標準滴定溶液體積的極差值不應超過0.06mL，取其平均值。                                                                                                                               &n

注：如試料在乙醇介質中滴定，則標定也應在相同介質中進行。                                                                                                                                  

隨同標定做空白試驗。                                                                                                                                  

按式(1)計算硝酸汞標準滴定溶液的實際濃度：

             （1）

式中：c—硝酸汞標準滴定溶液的實際濃度，moL/L；

c₁—氯化鈉標準溶液的濃度，moL/L；

V₁—氯化鈉標準溶液的體積，mL；

V—滴定氯化鈉標準溶液消耗硝酸汞標準滴定溶液的體積，mL；                                                                                                                                 

V

3.11溴酚藍指示劑，1g/L：用乙醇配制。

3.12二苯偶氮羰酰肼指示劑，5g/L：用乙醇配制。

4   儀器設備

10mL微量滴定管，精確至0.01mL。

5   操作步驟

5.1稱樣                                                                                                                                  

碳酸鋰預先在250～260℃烘2h，置于干燥器中冷卻至室溫。                                                                                                                                  

稱取3.000g試樣，精確至0.001g。                                                                                                                                 

獨立地進行兩次測定，取其平均值。                                                                         

5.2空白試驗                                                                                                                                 

隨同試料做空白試驗。但加入與分解試料等量的酸，應在低溫下蒸發至近干。                                                                                                                                  

5.3測定                                                                                                                                 

5.3.1將試料置于250mL三角瓶中，用少量水潤濕，加入6mL硝酸溶解。加水至約40mL(如試樣中氯質量分數小于0.008%時，加入30mL乙醇和4mL水)，加入2～3滴1g/L溴酚藍指示劑，用200g/L或40g/L氫氧化鈉溶液和調至藍色，再滴加硝酸(3+47)至恰呈黃色，并過量2～5滴。

5.3.2向試液(5.3.1)中加入1mL 5g/L二苯偶氮羰酰肼指示劑，用0.005moL/L硝酸汞標準滴定溶液滴定至試液由黃色變?yōu)樽霞t色即為終點。                                                                                                                                  

6   結果計算                &n

按下式(2)計算氯化物(以C1計)的含量，以質量分數表示：

           （2）                                                                                            

式中： c—硝酸汞標準滴定溶液的實際濃度，moL/L；

V—滴定試液消耗硝酸汞標準滴定溶液的體積，mL；                                                                                                                                  

V₀—滴定空白溶液消耗硝酸汞標準滴定溶液的體積，mL；

m—試料的質量，g；

0.03545—與1.00mL硝酸汞標準滴定溶液相當?shù)穆然�物的質量，g。

7   允許差

兩個測定值之間的的差值應不大于下表所列允許差。

%

8   參考文獻

[1] 國家標準GB/T 11064.10-89